I'm getting an OOS error when attempting to watch some replays I just made using 05X10. There are 5 replays in total.
I know that some of these errors have been reported before, but were mainly from downloaded sprs.

The sequence of events after I have saved the replay is:

• Select replay to load.
  
• The track loads up (if it needs to).
  
• Grey-ish screen appears with messages 'Can't load skin: xxxx' even though the skins do exist. (refer Screen1)
  
• Grey-ish screen will hang there until I escape out of the replay.
  
• Playing around a bit, I hit Shift+U and now could see the 'OOS Error' (referscreen2). I can't move at all in the Shit+U screen.
  
• In some of the replays, I can see cars etc after hitting shift+u, and notice that of the skins on the cars have not loaded. (refer screen 4)
  
• I have also attached one of the replays if that helps at all.

The problem also occurred a couple of weeks ago but seemed to go away, so I didn't worry about it.
I'm suspecting it's related to not being able to load the skins for some reason, but that's only a guess...
Any ideas?

...and here's the .spr

hehe look at the "test drive" it seems that your Ai's have a problem running the race.
the replay wouldn't start for me either, i had the same "skin" problems but in the test drive they were mostly on the cars.

Hehe, they went for a bit after you gave them a push start.
The AI was good* in the race from the bad replay, so I don't know why they would be stationary for the test drive.
Strange

*well, as good as the AI gets anyway

I've been experimenting.
The plot thickens...
3 replays are attached.
Replay1.spr
Does not work. Get message "can't load skin XFR_Pelican' among others, and the OOS error.
XFR_Pelican was my skin. I started a new race, but took myself out, so there were only AI racers left with an assortment of other skins. I let them race for a bit and saved Replay 2.

Replay2.spr
Replay works fine.
I then started a new race and put myself back in with the XFR_Pelican again, raced a bit and produced Replay 3

Replay3.spr
Works, but get this. My XFR_Pelican skin appears for one of the AI guys, and I get his skin!

I'm confused, but maybe there's something wrong with the way skins are loaded to memory for the AI?

Something is probably corrupting the replays when they are saved. Do a memory and harddisk test to see if there's something wrong there. You might also try with a clean install of LFS to see if that helps.

Thanks for the advise, but this isn't a hardware issue.
Memory test came up fine. I also ran LFS from a different physical disk and had exactly the same result.